一、空壓機每次運行前： 1、油氣桶泄水。 2、檢查油表油位。 3、配套設備準備。 二、空壓機運轉500小時后，需要以下操作： 1、空氣濾芯取下清潔，用0.2MPa以下低壓壓縮空氣由內向外吹干凈。 2、新機使用后**次換油過濾器。 3、更換冷卻液。 4、清潔空氣濾水杯的濾芯; 5、清潔泄水閥濾芯。 三、空壓機運轉1000小時后操作： 1、檢查進氣閥動作及活動部位，并加注油脂。 2、清潔空氣濾清器。 3、檢視管接頭緊固螺栓及緊固電線端子螺絲。 四、空壓機運轉2000小時或6個月： 1、檢查各部管路 2、更換空氣濾芯 3、更換油過濾器 4、更換空氣濾水杯的濾芯 5、更換自動泄水閥濾芯 6、補充電機的潤滑脂 五、空壓機運轉3000小時或一年： 1、檢查進氣閥動作情況及閥板是否關嚴。 2、檢查所有的電磁閥。 3、檢查各保護壓差開關是否動作正常。 4、更換油細分離器。 5、檢查壓力維持閥。 6、清洗冷卻器，更換圓型環。 7、更換空氣濾芯、油濾芯。 8、檢查起動器之動作。 First, the air compressor runs before each operation: 1, oil and gas pail drain. 2, check oil meter oil level. 3. Preparation of supporting equipment. Two. After running for 500 hours, the air compressor needs the following operation: 1, the air filter is cleaned and the compressed air below 0.2MPa is blown from inside to outside. 2. The first oil change filter after the new machine is used. 3. Replace the coolant. 4, clean air filter cartridge filter; 5, clean the drain valve cartridge. Three, air compressor running 1000 hours after operation: 1, check the intake valve action and active parts, and add grease. 2. Clean air filter. 3. Inspect the fastening bolts and fastening screw bolts. Four, air compressor operation for 2000 hours or 6 months: 1, inspection of the various parts of the pipeline 2, the replacement of air filter 3, the replacement of the oil filter 4, the replacement of the filter cartridge 5 of the air filter cup, the replacement of the automatic leak valve filter 6, the lubricating grease five of the motor, the air compressor operation for 3000 hours or a year: 1, check the air valve action. Whether the valve plate is closed or not. 2. Check all the solenoid valves. 3, check whether the protection pressure switch is normal. 4. Replace the oil fine separator. 5, check the pressure maintenance valve. 6. Clean the cooler and replace the circular ring. 7. Replace air filter core and oil filter core. 8. Check the action of the starter.